Commissioning a new Terracotta Tiled Floor in Warwickshire

Newly built properties are not without their problems and often take a while to resolve all the snagging which occasionally extends to resolving problems with newly laid tiled floors. At this new property in the village of Malvern, and overlooked by the Malvern hills, the builders had left the Terracotta tiled kitchen floor covered in grout smears (also known as Grout Haze) following installation. They had also neglected to seal the tiles, which was actually quite fortunate in this case as they would have sealed in the grout haze, making it more difficult to remove.

Naturally, the property owner wanted the problem to be resolved as soon as possible, and for me to make the tiles easy to keep clean in future, which can be achieved by sealing the tile.

Grout Haze Removed from new Terracotta Tiles at Malvern Village

Removing Grout Haze from a Terracotta Tiled Floor

Before starting work, I made sure to fully protect any exposed woodwork with a plastic sheet covering to protect them from potential damage. I then proceeded to give the floor a thorough clean, using Tile Doctor Remove and Go to clean the floor and eradicate some stains that had been left behind as a result of the building work.

Grout Haze Removed from new Terracotta Tiles at Malvern Village Grout Haze Removed from new Terracotta Tiles at Malvern Village

Next, I paid special attention to the grout, where the very visible problem of grout haze had arisen. To neutralise these smears I used Tile Doctor Grout Clean Up, a concentrated phosphoric acid cleaner that can also remove alkaline mineral deposits and efflorescence. Grout Clean Up is only to be used on acid resistant stone, as sensitive stone can suffer from irreparable etching if it comes into contact with the product.

Once completely clean and free of grout smears the floor was thoroughly rinsed with water to remove any trace of product and then dried as much as possible with a wet vacuum, afterwards an air mover was installed to speed up the drying process.

Sealing a Terracotta Tiled Floor

Later that afternoon the floor was dry and I was able to apply a sealer. To do this I opted to use several coats of Tile Doctor Seal and Go Extra, a topical, fully breathable sealer that works really well on Terracotta.

Grout Haze Removed from new Terracotta Tiles at Malvern Village

The sealer builds up a layer of protection on the surface of the tiles, protecting against ingrained dirt and stains. Seal and Go Extra also provides a high quality sheen finish which really did well to enhance the look of the Terracotta.

Grout Haze Removed from new Terracotta Tiles at Malvern Village

The property owner was exceptionally pleased with the results, and to have this problem dealt with quickly and efficiently, additionally the sealer will ensure the Kitchen floor is easy to keep clean in the future.
Source: Terracotta Tile Cleaning and Maintenance Service in Warwickshire

Reviatlising a Faded and Dirty Terracotta Conservatory Floor

Cranleigh is the self-proclaimed largest village in England, sitting about 8 miles southeast of Guildford in Surrey. One of its villagers contacted me recently to see if there was anything I could do to improve the state of their Terracotta tiled conservatory. They were in the process of completely redecorating the conservatory, having just replaced the wood and glass and I was called in to restore the tiled floor back to looking its best.

Terracotta is made from clay and is quite porous ceramic, and tends to be quite porous when made into commercial or residential tiling. Just like stone it needs to be sealed to ensure the pores don’t become ingrained with dirt, following that sealers do need to be maintained as they do wear off over time.

In this case, my client had moved into the property twenty years ago, and had only ever carried out a routine mop of the floor; as a result the floor was now ingrained with dirt and had lost its colour and would require a deep clean and seal to bring it back to life.

Terracotta Conservatory Cranliegh Before Cleaning Terracotta Conservatory Cranliegh Before Cleaning

Cleaning a Terracotta tiled conservatory

To begin with, I mixed a cleaning solution consisting of one part Tile Doctor Pro Clean to one part water. This was spread evenly across the floor and let to dwell for approximately ten to fifteen minutes. The solution was then agitated with a scrubbing pad fitted to my heavy-weight rotary machine, lifting away the initial layers of muck and any remaining old sealer.

However, I noticed after giving the tiles a rinse that some of the old sealer was still prevalent in some areas. To deal with this, I applied a solvent-based sealer stripper and left it to work its magic on the affected areas. After about an hour, I added a steamer to the mix, and this allowed me to thoroughly scrub away the old seal. This was followed up by another rinse of the floor, and left it to dry.

Terracotta Conservatory Cranliegh During Cleaning

Sealing a Terracotta tiled conservatory

I returned to the house five days later to complete the restoration. My immediate task was to carry out a moisture test to make sure the floor was completely dry and therefore ready to take the new seal, this is an important step as adding a sealer to a damp floor can result in problems.

Once satisfied, I proceeded to seal the floor with five coats of Tile Doctor Colour Grow sealer. This sealer is particularly effective at providing durable surface protection from within, and contains properties which enhanced the natural auburn shades in the Terracotta tiles.

Terracotta Conservatory Cranliegh After Sealing Terracotta Conservatory Cranliegh After Sealing

I’m pleased to say that my client was overjoyed with the quick transformation of their conservatory floor. They never knew quite how vibrant the colours in the stone could be, and better still, the floor now blends in with their newly painted lemon walls.

Terracotta Conservatory Cranliegh Before and After Cleaning

Source: Cleaning and Maintaining Terracotta Flooring in West Surrey